單工位旋轉噴淋清洗機在使用的注意要點

　　Key points to note when using a single station rotary spray cleaning machine

　　單工位旋轉噴淋清洗機在性能上有很大的提升。在時間、成本、效率都有不同程度的提高。雖然單工位旋轉噴淋清洗機功能強大，如果使用時不注意危害也不小，人不能長時間的靠近它。

　　The single station rotary spray cleaning machine has greatly improved performance. There have been varying degrees of improvements in time, cost, and efficiency. Although the single station rotary spray cleaning machine has powerful functions, if not careful during use, the harm is not small, and people should not approach it for a long time.

　　一般清洗機的雜音有60分貝左右，操作久了是非常難受的，其實超聲波你是聽不到的，你聽到的是清洗作用時與水于槽體發出的聲音。操作久了對聽力還是有影響的，在清洗房說話基本都是大嗓門，小嗓門別人根本聽不見

　　The noise of a typical cleaning machine is around 60 decibels, which can be very uncomfortable after prolonged operation. In fact, you cannot hear ultrasonic waves. What you hear is the sound made by the water in the tank during the cleaning process. Operating for a long time still has an impact on hearing. When speaking in the cleaning room, most people speak in a loud voice, and those with a low voice cannot be heard by others

　　超聲波的穿透力非常強的，你在茶杯里放上水，把茶杯放到洗槽里，杯里的水喝槽體的水不接觸，照樣你的杯子里的水有很強的空化作用，而孕婦去醫院照B超，那就是超聲波，因?yàn)榇┩噶軓?qiáng)。

　　The penetration power of ultrasound is very strong. If you put water in a teacup and put it in a sink, the water in the teacup will not come into contact with the water in the sink. However, the water in your teacup still has a strong cavitation effect. When pregnant women go to the hospital for ultrasound, it is ultrasound because of its strong penetration power.

　　超聲波在清洗的槽的水能夠空化作用，能在水里爆破，那么它在你的身體里，照樣是會有空化作用。也就是它穿過你的身體，一樣在你體液里清洗。

　　Ultrasonic waves can cause cavitation in the water of the cleaning tank and explode in the water, so they will still have cavitation in your body. That is to say, it passes through your body and is also washed in your bodily fluids.

　　單工位旋轉噴淋清洗機的使用注意事項：

　　Precautions for using a single station rotary spray cleaning machine:

　　注意要點：為了延長單工位旋轉噴淋清洗機使用壽命，建議將設備放在通風、干燥的區域，發生器后側的風扇孔應定期清潔。工業超聲波清洗機的排風扇需保持通風，以使氣流暢通無阻。

　　Attention: In order to extend the service life of the single station rotary spray cleaning machine, it is recommended to place the equipment in a ventilated and dry area, and the fan hole behind the generator should be cleaned regularly. The exhaust fan of the industrial ultrasonic cleaning machine needs to be kept ventilated to ensure unobstructed airflow.

　　當清洗缸體溫度為常溫時，切勿將高溫液體直接注入缸內，以免導致?lián)Q能器松動而影響機器正常使用。

　　When cleaning the cylinder body at room temperature, do not directly inject high-temperature liquid into the cylinder to avoid loosening the transducer and affecting the normal use of the machine.

　　當清洗液因污染而需要更換時，切勿將低溫液體直接注入高溫缸體內，這同樣可導致?lián)Q能器脫落，同時應當關閉加熱器開關，以免加熱器因槽內無液體而損壞。

　　When the cleaning solution needs to be replaced due to contamination, do not directly inject low-temperature liquid into the high-temperature cylinder, which can also cause the transducer to detach. At the same time, the heater switch should be turned off to avoid damage to the heater due to the lack of liquid in the tank.

　　清洗槽必須放入液體后才能開機工作，水位高度＞100mm（底振式）且水平放置，換能器在側面時，為清洗槽槽沿100mm處，如在空氣狀態開機會損壞機器。

　　The cleaning tank must be filled with liquid before it can be turned on for operation. The water level should be above 100mm (bottom vibration type) and placed horizontally. When the transducer is on the side, it should be located 100mm along the edge of the cleaning tank. If the machine is turned on in an air state, it will be damaged.

　　定期檢查換能器，切勿使其變潮及撞擊，以免造成不必要的損失。使用完畢后，應關閉總電源。關機后不要立刻重新開機，間隙時間應在1分鐘以上。

　　Regularly check the transducer to prevent it from becoming damp or being impacted, in order to avoid unnecessary damage. After use, the main power should be turned off. Do not immediately restart after shutting down, the gap time should be at least 1 minute.

　　本文由  單工位旋轉噴淋清洗機  友情奉獻.更多有關的知識請點擊  http://m.pvc-powder.com/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待

　　This article is a friendly contribution from a single station rotary spray cleaning machine For more related knowledge, please click http://m.pvc-powder.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Stay tuned